1004,West-CBD,No.139 Binhe Rd,Futian District,Shenzhen, China Post Code:518048
+86-18682200597
sales@szhaiwang.com
source:Industry News release time:2022-06-17 Hits: Popular:Infrared sensing module
Ordinary switching power supplies use NTC and relays in parallel. NTC is essentially a negative temperature coefficient thermistor. The higher the temperature, the lower the resistance value. The function used in the power supply is to suppress the inrush current during startup. The temperature of the NTC is low at the moment of startup, and the resistance value is large, which suppresses the inrush current. , and then the NTC temperature rises, the resistance value drops, and it has been reduced to a very low level without power consumption. However, if the machine is repeatedly turned on and off in a short time, and the NTC has no time to cool down, the resistance value will always be very low, and the current cannot be suppressed, and the protection cannot be achieved, so a relay needs to be connected in parallel. It cools down and the next boot is ready to go right away, so it's the best of both worlds.
However, in some switching power supplies, such as inverter air conditioners, PTC and relays are used in parallel. PTC is also a thermistor with a positive temperature coefficient, that is, the higher the temperature, the greater the resistance. what about this?
Because the air conditioner, especially the inverter air conditioner, needs to charge the large capacitor when it is turned on. In addition, the starting current of the compressor is also large, which has a great impact on the power supply and is easy to burn out the circuit. Therefore, PTC is used. After the PTC temperature rises, the resistance increases. Large, the control current should not rise too fast, let the outdoor unit circuit "slowly" wake up, after normal operation, the relay will pull in, short-circuit the PTC, and prevent a high voltage drop across the PTC, because at this time the PTC resistance high value. Of course, no power is consumed after being short-circuited. If there is an abnormality during the boot process, the main relay does not pull in, and the PTC resistance becomes large as the temperature rises, which plays the role of blocking the current, similar to the fuse blown (of course not completely blown).
Therefore, the reason why the air conditioner uses PTC instead of NTC is mainly because the inrush current of the air conditioner is larger and the time is longer. Therefore, the control requirements for the inrush current are higher than those of ordinary switching power supplies, and PTC can be used to "continuously" control the current. The increase of , gives the back-end main control circuit a "slow" start-up time, and at the same time plays a protective role in the event of an abnormal start-up.
Read recommendations:
Dryer suitable for NTC temperature sensor
Popular Recommended Products
PIR Lens 003
2021-12-09PO170
2021-11-27Φ12mm size
2021-11-27HW-MD6 microwave sensor module
2021-12-07PIR Lens 002
2021-12-098308-A PIR lens
2021-12-17TP-L80
2021-11-27PIR Lens 8140
2021-12-09Φ12mm size with metal case
2021-11-27PIR Lens 8019
2021-12-09HW-MS07 microwave sensor module
2021-12-07Independent linear lithium battery charger with a thermistor input input.Small Human Body Sensor
2023-06-10NTC temperature sensor that can be used for the full contact of the human body.Pyroelectric infrared
2023-04-06NTC temperature sensor applicable to smart clothing
2023-02-10Enameled wire NTC thermistor IQC quality test report.alarm sensor direct sales
2022-10-08How to check and judge whether the ntc thermal protector is good or bad?5.8G Frequency microwave sen
2022-06-02NTC critical temperature thermistor resistance
2023-06-02Introduction to long life NTC thermist resistance.Ultrasonic module price
2023-05-18NTC temperature sensor for fruit tree seedling cultivation and irrigation equipment
2023-09-21Three control states of ntc temperature control switch
2022-05-19NTC thermistor for smart electric foot bucket
2022-08-26szhaiwang4@hotmail.com
+86-18682200597
sales@szhaiwang.com